What?! There Is A Capacitor in My Transformer?

时间： 2020-12-02 来源：Exxelia

技术问答

EXXELIA recently designed an auxiliary transformer for a spacecraft application, where interwinding capacitance was of concern to the customer. The controller chip they were using in their power supply was noted to be “rather sensitive to excess capacitance.”

Exxelia has also supplied thousands of driver transformers for use in a subsystem of the AN/TPQ-53 Radar System in which interwinding capacitance within the toroidal windings is held to a very demanding tolerance.

But what is interwinding capacitance?

Capacitance in a transformer winding cannot be avoided. The voltage difference between turns, between winding layers and from windings to the core, creates “parasitic” capacitances in the transformer circuit. These capacitances are shown as Cp, Cs, and Cw in this schematic diagram of an electronic transformer “equivalent circuit.”

Interwinding and distributed capacitance occur in transformers due to the physical separation of, and electrostatic coupling between, different turns of wire. In general, the capacitance presents itself between the different layers within a winding and between the outside layer of one winding and the inside layer of the next.

In conventional magnetics, interwinding capacitance is a function of coil configuration – the geometry of adjacent conductors and separating dielectric media. Specifically, it is directly proportional to the shared surface area of the windings (shown in green and red below), the dielectric constant of the insulator between the windings (shown in gray below), and is inversely proportional to the separation distance through the dielectric media.

In high-frequency transformer design, leakage inductance and capacitance are often competing design requirements since the beneficial parameters that provide low leakage inductance also tend to increase the interwinding capacitance.

Excessive capacitance can cause undesirable common-mode noise transmission between transformer windings or between transformer windings and core or another ground connection.

Exxelia can assist with these design challenges when creating products that have to deal with interwinding capacitance, for all types of magnetic components.

Important coil configuration design considerations must be made when capacitive coupling causes unacceptable signal transmission (for example, common-mode noise transmission or undesirable spurious ringing on a high voltage output). Windings may be configured in a way that reduces the dV/dt voltages induced across dielectric media. Conductive screen(s) tied to preferred potential(s) can also be added between adjacent windings to reduce transmission.

发送到邮箱 |
+1 赞 0
收藏
评论 0
| 转发至：

本文由翊翊所思转载自Exxelia，原文标题为:WHAT?! THERE IS A CAPACITOR IN MY TRANSFORMER?，本站所有转载文章系出于传递更多信息之目的，且明确注明来源，不希望被转载的媒体或个人可与我们联系，我们将立即进行删除处理。

全部评论（0）

暂无评论

Elevating AED Performance With Exxelia Ohmcraft Resistors ＆ Alcon Power Film Capacitors

Exxelia Ohmcraft Resistors and Exxelia Alcon Power film capacitors, engineered specifically to elevate the performance and reliability of AED devices.

应用方案发布时间 : 2024-01-10

【应用】Exxelia介质谐振器用于X波段雷达模块，易起振、可稳定调频

本文主要介绍Exxelia的介质谐振器E21936D5.1F10525+/-100MHZ介质谐振器在X波段雷达模块上的应用，具有易起振，频率稳定可调，噪声低等特点，可保证产品稳定可靠工作。

应用方案发布时间 : 2020-10-14

【成功案例】Exxelia C系列电容在汽车PTC中的应用，满足2020贴片电容空间要求

Exxelia的C系列电容，容量10pF~1.2uF，耐压最高到10kV，符合车规级要求。按照客户汽车上PTC项目的要求，可以轻松选到耐压2000V，10nF容量，2020贴片封装的型号。客户也对该型号电容表示满足。该系列的电容交期也比较好，不像其他品牌高压陶瓷电容需要30周以上的交期。

应用方案发布时间 : 2019-01-04

Exxelia 绕线磁性元件选型指南

目录- Company profile Wound Magnetics Component ENGINEERING SUPPORT High-Grade Technologies High Power Technologies Standard Technologies High-Grade Products Standard Products Built-to-Print Design Specification Form

型号- 3201008 AA 681 G,SBIT # 7.5S,MSCI 10 000 022 X Y 10,3201009 06 470 K,TCM22 1M5 H,ESI 01 M15 1X,TCM14 XXX H,3201009 03 560 K,3201008 AA 330 G,CMC 22 XXX 2WR SERIES,CMC22 1M6 2WR,MPCI H01 2K0 1XY,3201009 02 ### Y,DLEF 42,M83446/5-16*,CMC 22,ESI 7 8K4 1S,M83446/10-51**,MPCI 10 001 000 X Y 5,MSCI 12 470 000 X Y 10,MPCI 233 002 700,MSCI 12 560 000 X Y 10,* 20 082 000 X Y 10,3201008 05 3L4 L,HTSE47-5M6-10SR,MSCI 10 003 300 X Y 10,3201009 08 111 K,SESI 9.1 6K2 2WR,3201008 AA L022 K,M83446/5-15*,3201008 AA L022 J,DBIT X 7 P10A,CMC 14 ### XWR,SESI 32 4K9 1PR,SESI 22 10K 2WR,CMC 14,CMC 15,M83446/10-86**,CMC 17,3201008 AA 681 K,CMC 18,3201008 AA 681 J,SESI 18.1 W,3201009 01 470 K,3201009 02 6L4 M,SESI 32 84K 1PR,M83446/5-14*,DBIT 2 7S,CMC17 13M,SESI 9.1 M33 1WR,CCM25 M22 1W,EFD 20 SMD,WRFT42 13R 1X,3201009 07 ### Y,CMC 15 1M0 2WR,3201009 02 8L0 M,DBIT 1 7P10,MSCI 10 002 200 X Y 2,MSCI 10 002 200 X Y 5,MPCI 233 150 000,M83446/5-13*,SESI 9.1 10K 2WR,MPCI 12 680 000 X Y 5,MPCI H01 7K1 1TS 15,MPCI 10 006 800,CT91 075 231 WR,MSCI 12 068 000 X Y 5,HTSE,MPCI 233 560 000,M83446/10-64**,CCM 6 10K 1W,SESI 32WR,TT17,TT14,TT12,3201008 AA 121 G,SESI 9.1 26K 2WR,MSCI 10 000 033 X Y 5,TT19,SESI 15 33K 1SR,MPCI 12 027 000 X Y 5,MPCI 10 000 010 X Y 10,MPCI 12 027 000 X Y 2,* 20 000 010 X Y 10,HTSE47-10K-6SR,TT20,MSCI 12 270 000 X Y 10,M83446/10-95**,HTSE18-85K-1WR,SESI 14 M18 1SR,TT07,TT05,MPCI 12 018 000 X Y 5,MPCI 12 018 000 X Y 2,CMC18 M54 2WR,3201009 03 1L8 N,MSCI,MSCI H01 12K 1TS 15,TT09,TT08,MPCI 12 150 000 X Y 5,MSCI 10 000 220 X Y 10,MPCI 12 033 000 X Y 10,3201008 AA L18 K,3201008 AA 121 J,3201008 AA 121 K,M83446/5-19*,SESI 32 12K 1#R,3201009 03 120 M,MSCI 12 330 000 X Y 5,3201009 01 3L3 M,3201008 AA 561 G,HTSE91-65K-1WR,3201009 03 680 K,ESI 01 2K7 1X,M83446/5-18*,3201009 05 330 K,SESI 32 36K 1WR,TCM19 XXX V,3201009 05 681 K,M83446/10-73**,MPCI 233 000 270,DBIT 8 7P10,3201009 06 341 K,TT29,3201008 AA 2L7 K,CCM25 33K 1W,TT26,TT25,DBIT 5 7X400,PP-C4-9-1270,CMC 22 3M3 2WR,MPCI 10 000 470 X Y 5,SESI 9.1 M10 2WR,TCM22 47M H,MPCI 20 680 000,3201008 AA 330 K,3201008 AA 330 J,3201008 AA 561 J,3201008 AA 561 K,M83446/5-17*,HCESC10 56K 1X,SESI 32 M11 1WR,PPCDR-C20-35-565,3201008 AA 2L7 G,3201009 05 4L3 M,3201008 AA 2L7 J,MSCI 12 270 000 X Y 5,CCM 5 22K 1W,3201008 AA 4L7 G,MPCI 233 004 700,MPCI 10 001 500,MSCI 10 000 470 X Y 10,3201008 05 4L6 L,3201008 AA 4L7 J,SESI 9.1 M15 1WR,3201008 AA 4L7 K,HTSE XX WR,MSCI 12 120 000 X Y 10,SESI 32 53K 1#R,MSCI 10 004 700 X Y 2,MPCI 233 003 900,MSCI 10 004 700 X Y 5,SBIT 1 7.5S,SESI 15 M10 1WR,CMC14 M14 XWR,MSCI 10 000 068 X Y 5,MPCI 233 470 000,SBIT 8 7.5S,FW-C25-20-989,M83446/10-33**,SBIT 1 7.8P,* 20 056 000 X Y 10,SESI 15 6K4 1WR,3201009 02 1L5 N,SESI 22 33K 2WR,SESI 32 M83 1PR,3201009 08 360 M,CMC 18 60K 2WR,CMC22 M34 2WR,TCM19 3M3 V,CCM 20,SESI 18.1 WE,M83446/10-68**,ESI 7 K42 1S,MPCI 20 056 000,MSCI H01,CCM 25,TCM23 4M2 V,MPCI 233 220 000,3201009 08 120 N,CCM25 M10 1W,M83446/10-121**,3201009 02 820 K,MSCI 12 018 000 X Y 10,MSCI 10 000 082 X Y 10,CT 91 XXX 231 WR,EFD 15 SMD,M83446/10-99**,SESI 32 M83 1WR,MPCI H01 K38 1TS 15,SESI 32 M20 1WR,SESI 14 82K 1SR,ESI SERIES,SESI 32 4M7 1WR,GDT15 M50 60 1WR,SESI 32 36K 1PR,CMC22 M14 2WR,3201009 05 151 K,* 20 003 900 X Y 10,CMC18 1M1 2WR,M83446/10-42**,HCESC10 M47 1X,CMC18 2M4,MPCI 10000 SERIES,MPCI 233 12K H01 1X,MSCI 10 000 033 X Y 10,CCM 20 23K 1W,SESI 15 M10 1SR,3201009 08 351 K,HCESC10 56K,3201009 05 1L5 N,DBIT 2 3S,3201008 AA L27 K,MSCI H01 1K5 1TS 15,SESI 22 2M2 1WR,M83446/10-77**,3201009 01 150 M,MPCI 20 270 000,SESI 32 M11 1PR,MPCI H01 K67 1XY,HTSE15-M10-1WR/SR,3201009 03 151 K,3201008 AA 3L9 J,3201008 AA 3L9 K,* 20 022 000 X Y 10,3201008 AA 3L9 G,CCM 6 ### #W,SESI 15 56K 1SR,3201009 03 480 K,TCM23 10M V,CMESC17 1M2 1H,DBIT # 7 SA,MSCI 10 001 500 X Y 10,MPCI 12 047 000 X Y 10,M83446/10-20**,HTSE22-M71-1WR,M83446/10-59**,HTSE47-15K-6SR,3201008 AA 391 K,M83446/5-60*,CT91 050 231 WR,SESI SERIES,3201008 AA 391 J,3201008 AA 391 G,DBIT 8 7P*,3201008 AA L018 K,SESI 9.1WR,HTSE91-M31-1WR,CCM 20 3K3 1W,CCM25 2M2 1W,3201009 02 121 K,3201009 04 101 K,3201009 07 472 K,CCM 6 2M2 1W,SESI 18 WR,SESI 22 19K 2WR,TCM18 1M1 V,WRFT 4X SERIES,M83446/10-02**,HTSE22-17K-1WR,MSCI 10 001 800 X Y 5,M83446/10-37**,SESI 14SR,3201009 02 2L7 M,CCM 5 M10 1W,M83446/10-103**,3201009 03 160 M,3201010 01 402,WRFT42 5R0 1X,SESI 18 15K 1WR,M83446/10-90**,MPCI 20 015 000,3201009 02 232 K,MSCI H01 SERIES,MPCI 20 820 000,MPCI 12 012 000 X Y 10,3201008 AA 151 K,3201008 AA 271 K,3201008 05 1L0 L,CCM 6 68K 1W,3201009 02 330 M,3201008 AA 271 J,CCM 6 1M0 1W,MSCI 10 000 820 X Y 5,MPCI H01 M10 1TS 15,MPCI 10 000 820 X Y 5,3201008 AA 271 G,MSCI 10 000 560 X Y 5,MSCI 12 390 000 X Y 5,DBIT 8 7PA,SESI 15 ### #WR,SESI 32 73K 1#R,* 20 068 000 X Y 10,MSCI 10 000 039 X Y 10,3201009 08 730 K,* 20 000 039 X Y 10,MSCI 10 001 800 X Y 2,3201009 04 221 K,MPCI 12 1000 000 X Y 5,CMESC17 69M 1H,CMESC17 13M 1H,GDT91 6M0 135 1WR,* 20 001 000 X Y 10,3201008 AA L10 K,M83446/5-64*,TCM28 10M H,M83446/06-17,M83446/06

选型指南 - EXXELIA - 05/23 PDF 英文下载

PRODUCTS & Solutions

型号- 30 S4,SESI 9.1,731P,TEV,SCT,SESI 18,SESI 15,TEP SERIES,TEV SERIES,SESI 14,AS31,DLEF 42,C4N SERIES,CTS23,KM 111,CM12,C4E,CTS21,132P,CMC 22,ST79 SMD,253P,KM 915,FP-5-200,CT79 SMD,KM 78,KM 311-KM 21,OP SERIES,C4N,CEC,CA 158,CTC42,CTS41,744G,SC SERIES,SESI 22,CNC5X,PMR 64,CER,SPE0844S,CTC3E,NHB SERIES,CTS33,DBIT,CTS32,CMC 14,CA 152,CMC 15,KM 501-601,KM 82,MML-M SERIES,CMC 17,XBL SERIES,CMC 18,MML-C SERIES,KM 711-KM 7,CK SERIES,842P,SESI 32,FLYT,PMR 4,CT79E,MTLM 1234 MIL,PMA 64 T,C SERIES,TXR,CNC SERIES,CFS,TCK SERIES,KM 111 S,KM 111 T,MSCI 10000,CS SERIES,CE,710P,CF,SV,A 64 S4,CTC21,MIL-PRF-83421/06,HTSE 47 SR,MPCI 10000,CNC3X,ST79 HT200,CTS1M,R SERIES,HCESC,KCP 4 UA T,CTS4,CTS1,CTS13,MRA HT,734G,MKT,P.P.S 16 R,CFS SERIES,CNC5X SERIES,MKRS,MPA HT,SHD,CA 20,735P,PM 90,CA 30,PM 94,MP-4A,ESI 01,560P,SHR,KM 94S,CTC4,PM 980,CTC3,700P,HVD SERIES,XBL,PMA 64,PM 98,CM 04,PM 96,KPF-9,MPCI 12000,TKD,CA 40,WT83,CEC SERIES,FP- 60-700,682P,HVR SERIES,R 73 A,MPCI 233 H01,GDT 15,PM 720,DSCC 10004,810P,442P,430P,684P,SHR-SERIES,BIK SERIES,FL SERIE,CT79 HT200,KM 90,AP31,DMC 22 XXX 1WR,R 73 R,KM 97,PP 78 SERIES,C4E SERIES,KM 94,CT4E,CL SERIES,PM 730,TCF SERIES,BIK,431P,CA 15,SH SERIES,859P,CA 2,CA 1,MP4,PM 7,CT 91,HVA,AP41,HVD,SV SERIES,PM 90 S,CT 05 XXX 231 W,PM 948 S,MML-D SERIES,WS83,MML-D,MML-C,CTC4RSE,FLYT SERIES,HVR,LA SERIES,PM 948,CCM 6,CT79,MML-M,CCM 5,CCM 4,PM 50,TBC SERIES,A 74 S4 T,MPCI 20000,SPE0844,HTSE XX WR,BPM SERIES,PM 907 S,ST79,SHD-SERIES,KM 311-KM 21 T,PM 60,CNC,KM 50-60,880P,DCL-41,ESI 7,CT9E,KM 711-KM 7 T,882P,410P,CNR,CTC42E,CMR 07,TKD SERIES,MIL 39006/22,MKT S,CMR 04,CT 01 100 261 X,DSCC 93026,TCL SERIES,MIL 39006/25,CT 08 200 221 PR,PMR 4 T,TCH SERIES,C3N SERIES,CF SERIES,UBL,CN SERIES,PR 3 A,PM 96 T,PM 96 S,DCL-50,PRA HT,CTP42,UBZ,RA ...,KM 501-601T,DFC-11,FP-7-300,CEC5X,UBL SERIES,WRFT 4X,CCM 20,PP 3 M,HT SERIES,MSCI H01,CER SERIES,CCM 25,CMESC,PP 318,KPF,218P,860P,CEC5X SERIES,SMT47,CT79E HT200,PP 78,PM 907,PP 3 A,BI 73 R,PR 3 M,TBC,P.P.S 16 A,C3E SERIES,HVA SERIES,SBIT,KP-3C,CT 15 200 231 WR,KM 50-60T,DCL-14,TCN8X,P.P.S 13,HTSE XX SR,CTC21E,CTP21,TCN8X SERIES,PM 12,MPCI 233,TCF,TCE,TCH,TCL,DCL-23,TCK,TCN,BPM,CTS21E,TCM,PP 418,A 64 S4 T,FP-1-400,CNC3X SERIES,TCX,NHB,DCL-6,GDT 91,CMESC SERIES,MSCI 20000,TCM SERIES,CTS41RSE,CH SERIES,FP-11-500,PMR 64 T,30 S4 SERIES,CE SERIES,709G,CP SERIES,CT4,MPCI H01,TEF SERIES,PM 94 S,730P,CT9,730G,A 74 S4,FP-8C-1500,FP-4-150,CNR SERIES,C3E,TEF,UBZ SERIES,PS ...,CT 10,SCT SERIES,TEP,CT79E SMD,C3N,BI 73 A

快速参考指南 - EXXELIA - November 2022 PDF 英文下载

Exxelia Expands Footprint in India with Strategic Investment in SVM

Exxelia, a leading designer and manufacturer of high-performance passive components and sub-systems, announces the acquisition of 70% of SVM Private Limited, a prominent Indian company specialized in the design and manufacturing of critical magnetic components and busbars, specifically serving the healthcare and industrial end-markets.

原厂动态发布时间 : 2024-11-12

Exxelia‘s Smart Magnetic: Breakthrough Technology for More Compact and Powerful Converters

The solutions provided by Exxelia‘s Smart Magnetic project are revolutionizing the field of electrical converters by offering unparalleled performance in terms of power density. Exxelia‘s Smart Magnetic technology offers multiple functional, economic and environmental benefits.

新技术发布时间 : 2023-08-01

Exxelia 商业航空用无源元件选型指南

描述- Exxelia brings its know-how to Aircraft, Helicopters and OEM manufacturers in numerous platforms for all types of critical functions including cockpit & avionics, engine & controls, actuation systems and power generation & distribution.

型号- PP,KM SERIES,TCF SERIES,DSCC 10004,BIK,CTC 21 SERIES,BIK SERIES,CCM,SESI,SH SERIES,CC SERIES,DSCC 93026,M39022,TCN SERIES,TCF,PM9X,CH SERIES,M83421,PM9X SERIES,CTC 21,TCN

选型指南 - EXXELIA - 2023/6/12 PDF 英文下载

Exxelia 卫星用无源元件选型指南

描述- From Space exploration to New Space constellations, from launchers to military satellites, Exxelia offers the capacitor, inductor, transformer, resistor, EMI-filter, potentiometer and tailored to the reliability level you need.

型号- DSCC 10004,HVR,PM 948S,SESI,DSCC 93026,MPCI 2000,CNC SERIES,CMC,NZ SERIES,TCF SERIES,CEC,HVD SERIES,PM 907S,PM 94S,PM 90S,CCM,CNC 3X,CEC SERIES,CNC 5X,TCF,HVD,E7000,CNC,HT SERIES,CTC 21 E,CTC 21

选型指南 - EXXELIA - 2023/6/12 PDF 英文下载