C-V Curve Matters for Quiet Power Electronics

时间： 2021-06-23 来源：fastSiC

技术问答

选型帮助

研发客服

商务客服

Si SJ MOSFET,silicon super-junction MOSFET,即思创意

Key Takeaways:

·Abrupt change of Cgd causes uncontrolled high dV/dt during switching transients results in oscillations and generates EMI.

·Abrupt change of Cgd with Vds has an adverse effect on EMI/EMC. Device with a smoother C-V curve performs better.

·Abrupt change of capacitive ratio Cgd/Cgs with Vds also adversely impacts EMI/EMC, smoother is better.

A paper published by ST Microelectronics at PCIM Europe 2014 discussed how the intrinsic capacitances of power MOSFETs may affect the electromagnetic interferences (EMI) and electromagnetic compatibility (EMC) of power electronics. In addition to the factors usually mentioned such as "component's placing on printed circuit boards" or "parasitic tanks created by traces and dielectric insulation", the parasitic parameters of power MOSFETs, particularly how the capacitances change with drain-to-source voltage Vds, could also affect the performance of EMI/EMC.

The authors compared two devices with similar parameters except for the characteristics of capacitance versus voltage (C-V) curves. One of the devices has a more linear, gradual change of capacitance with Vds, the other one has a highly non-linear, abrupt change of capacitance with Vds. And they found that the device with an abrupt drop of capacitance resulted in a high-frequency oscillation of Vds and Vgs, and generated significantly higher EMI exceeding the regulation required maximum value. This is because during the charging and discharging of MOSFET reverse transfer capacitance (Crss, or Miller capacitance, Cgd), a sudden change of capacitance would result in very high dV/dt, which coupling with other parasitics, would then cause oscillations.

Besides the shape of CV curves, the authors also found that the shape of capacitive ratio (R) between Cgd and Cgs (R=Cgd/Cgs or Crss/Ciss) with Vds also has an impact on the performance of EMI/EMC. Similar to C-V curves, a smoother R-V curve performs better on EMI/EMC.

Similar observations were also found in another paper published at IEEE ICSICT 2016 by authors from Peking University, Fudan University, and Suzhou Oriental Semiconductor. The abrupt change Cgd in silicon super-junction MOSFET (Si SJ MOSFET) is originated from the merged depletion layers from adjacent p-type pillars which suddenly reduce the capacitance to a very low value. This abrupt change of Cgd would result in an abrupt change of voltage drop on the series gate resistor during the charging and discharging of Miller capacitance, cause oscillations of gate voltage and drain voltage, and generate EMI. With all other factors kept the same, devices with smoother C-V curve could provide more EMI margin compared to devices with abrupt Cgd change and thus enable higher switching frequency. Newer generations of Si SJ MOSFETs usually exhibit a more abrupt change in Cgd because of reduced cell pitch, this may be one of the reasons why it often requires more efforts to deal with the EMI/EMC issues when using newer generations of Si SJ MOSFETs.

发送到邮箱 |
+1 赞 0
收藏
评论 0
| 转发至：

本文由热心市民小陈转载自fastSiC，原文标题为:C-V curve matters for quiet power electronics，本站所有转载文章系出于传递更多信息之目的，且明确注明来源，不希望被转载的媒体或个人可与我们联系，我们将立即进行删除处理。

全部评论（0）

暂无评论

【经验】解析C-V曲线对功率MOSFET EMI能力的影响

本文即思创意介绍C-V曲线对功率MOSFET EMI能力的影响。在开关瞬变期间，Cgd的突然变化会导致不受控制的高dV/dt，从而导致振荡并产生EMI；Cgd与Vds的突然变化对电磁干扰/电磁兼容有不利影响。

设计经验发布时间 : 2022-10-13

Why Using Newer Si SJ MOSFETs May Not Be a Good Idea for High Frequency Switching

Resonant switching techniques are used to reduce the switching loss and increase the power density. Output capacitance (Coss) related loss is the major switching loss in resonant soft switching. However, under the similar on-resistance, new generations of silicon super junction MOSFET are actually dissipating more energy, and Ediss of silicon super junction MOSFET tends to increase with increasing frequency. Silicon super junction MOSFETs are less suitable to be used in resonant topologies targeting high frequency operations.

设计经验发布时间 : 2021-06-22

Achieve Zero Switching Loss with SiC MOSFET

A technical report published in IEEE Transactions on Power Electronics, demonstrated that the switching loss of SiC MOSFET can be completely eliminated under some control strategies.The study was conducted by Prof. Alex Q. Huang’s group at University of Texas at Austin and Prof. Bo Zhang’s group at University of Electronic Science and Technology of China.

设计经验发布时间 : 2021-10-16

650V Enhancement-mode SiC MOSFET Provides Qoss Almost 1/10 of Advanced Silicon Super-junction MOSFET

Our enhancement-mode SiC MOSFET provides Qoss almost 1/10 of advanced silicon super-junction MOSFET and close to GaN FET. The Rdson@100C is only 10% higher than Rdson@25C, enables better Rdson@100C*Qoss figure-of-merit (FOM) better than GaN. The driving method of our SiC MOSFET is similar to that of silicon power MOSFET and the dV/dt is easily and fully controllable by adjusting external gate resistance (Rg,ext). The much higher avalanche energy (EAS) density (close to 20J/cm2) enables the EAS rating similar to advanced silicon super-junction MOSFET despite with a much smaller chip size.

厂牌及品类发布时间 : 2021-06-07

FH06004 Silicon Carbide Merged PN-Schottky Diode

型号- FH06004,FH06004Z,FH06004Y

数据手册 - 即思创意 - Nov. 2022 PDF 英文下载

即思创意（fastSiC）碳化硅MOSFET和肖特基二极管选型指南

目录- SiC Schottky Diode&SiC MOSFET

型号- FL12190A,FF06100G,FC06008D,FF06100F,FC06006A,FC06008C,FC06008B,FF06100D,FC06008A,FF06320B,FF06320A,FF06030Q,FF17900E,FH06010C,FH06020E-3,FL06320B,FH06020E-2,FL06320A,FC06006D,FC06016C,FC06006C,FF17900Q,FC06010C,FH06004C,FH06006C,FC06002X,FL06150A,FL06320G,FF061K4A,FF12040Q

选型指南 - 即思创意 - 2022/1/18 PDF 英文下载

即思创意碳化硅肖特基二极管及MOSFET选型表

即思创意提供以下参数的技术选型,DC Blocking Voltage(V):650,Total Capacitive Charge(nC):10~45,Capacitance Stored Energy(μJ):1.6~6.5,Continuous Drain Current(A):2.5~60

产品型号	品类	Power Dissipation(W)	Continuous Drain Current(A)	Gate Charge(nC)	Output Capacitive Charge(nC)	Avalanche Energy(mJ)
FL12190A	碳化硅肖特基二极管	88	10	30	41	200

选型表 - 即思创意立即选型

即思创意（FSS）是台湾一家专业的碳化硅功率器件供应商，专注于可降低切换损耗适用于高频操作的超低电容电荷碳化硅肖特基二极管及碳化硅MOSFET。‍全系列采用寄生电感小、小型化、表面贴焊的DPAK及QFN5x6封装。世强是即思创意官方授权一级代理商，代理即思创意碳化硅功率器件，库存丰富，正品保证。

碳化硅肖特基二极管碳化硅MOS管

授权代理商 - 深圳市世强元件网络有限公司线上商城技术资料

展开

FF06030 Silicon Carbide MOSFET Product Datasheet

型号- FF06030,FF06030Q,FF06030E-3

数据手册 - 即思创意 - Rev. Tentative - Nov. 2021 PDF 英文下载查看更多版本

FL06100 Silicon Carbide MOSFET Product Datasheet

型号- FL06100F,FL06100G,FL06100

数据手册 - 即思创意 - Rev. Tentative - Mar. 2022 PDF 英文下载

【产品】FL06100系列650V/100mΩ碳化硅MOSFET，可兼容标准栅极驱动器，具有高雪崩耐受能力

即思创意推出FL06100系列碳化硅MOSFET（650V，100mΩ），可兼容标准栅极驱动器，具有高雪崩耐受能力及高可靠性，大大提高系统效率，采用薄型低寄生电感封装，结温/储存温度为-55℃至175℃，应用前景广阔。

产品发布时间 : 2023-03-01

FH06010 Silicon Carbide Merged PN-Schottky Diode Product Datasheet

型号- FH06010D,FH06010C,FH06010

数据手册 - 即思创意 - Rev. Preliminary - Oct. 2021 PDF 英文下载

SiC is quickly taking the market share originally occupied by Si IGBT in electric vehicles

With SiC inverters, it is possible to extend the range of EVs by 6~10% with the same size of battery pack, or maintain the same range with a smaller battery because of its high efficiency and high frequency operation capability. It can be sure that SiC will continue to replace Si in EVs, not just in main inverters, but also on-board chargers (OBC) and DC/DC converters, probably faster than anticipated.

行业资讯发布时间 : 2021-10-14