Flexible Interface of the ZSSC3241 Enhanced Sensor Signal Conditioner Enables Bridge as Temperature Sensor

时间： 2023-05-26 来源：RENESAS Blogs

技术问答

Accurate measurement using sensor elements requires precise and local measurement of the element’s temperature for correction and compensation across a wide operating range. Therefore, an integral part of Sensor Signal Conditioner (SSC) functionality is to provide one or more methods to measure the temperature of the sensor element, which is typically a resistive bridge or capacitive transducer.

Often, the sensor element may be separated from the SSC by several centimeters or more. In these cases, an SSC cannot be used predictably for temperature compensation and some type of external thermometer is needed that can be co-located with the bridge sensor.

For resistive bridges, the ultimate way to measure the sensor temperature accurately with no additional cost or space is to use the temperature coefficient of the bridge itself. But this requires further complexity in the biasing circuitry for the sensor bridge as well as more sophisticated calibration algorithms in the SSC to linearize the temperature coefficient of the bridge (which may exhibit up to third-order variation).

With the ZSSC3241 Enhanced Sensor Signal Conditioner, the ability to use the temperature coefficient of the bridge for accurate sensor temperature measurement is fully integrated and supported.

Flexible Temperature Measurement with the ZSSC3241 High-End SSC

The SSC can support temperature measurement using an internal PTAT, external diodes, or thermistors, and using the main sensing bridge itself as the thermometer. The various options are fully programmable and configurable using internal Non-Volatile Memory (NVM) for optimal performance based on system requirements.

The basic block diagram for the ZSSC3241 shows the configurable sensor interface with biasing and amplification functions in the analog front end. There is also an Internal Temperature Sensor onboard. The ADC converts the sensor and temperature readings into the digital domain, where all the linearization, correction, and temperature compensation functions are performed. The final calibrated and scaled outputs are available as either analog or various digital representations.

Figure 1. Block Diagram of the ZSSC3241 Sensor Signal Conditioner (SSC).

A close look into the analog front end shows there are four blocks in particular that enable the ZSSC3241 to reconfigure temperature measurements: a sensor-supply multiplexer to switch between current and voltage bias modes, a sensor bias current source, an internal temperature sensor, and an input multiplexer that selects between the measurands. These blocks are controlled by bits in the NVM labeled sensor_sup, Tbiasout, and gain_polarity.

Figure 2. Configurable blocks of the Analog Front End interface to the bridge and temperature sensors.

The ZSSC3241 provides 7 different temperature measurement modes

With these blocks and the configuration options, the ZSSC3241 provides 7 different temperature measurement modes as summarized in the table below. There are two primary biasing modes for using the sensor bridge as a thermometer: current and voltage. For each of these types, a series resistor, Rt, is required to adjust the common mode voltage of the bridge into the proper range for the internal Programmable Gain Amplifier (PGA). The ZSSC3241 provides the option to have this series resistance fully integrated for many cases, but some external resistance might be required in cases where accuracy requirements are stringent.

Table 1. Summary of Temperature sensing options in the ZSSC3241. The references T1-T6 correspond to labels used in the datasheet.

With its wide range of front-end configurations, the ZSSC3241 enables designers to optimize both the main sensor interface and the type and location of sensors used for temperature compensation, achieving the best accuracy possible with fewer components and costs.

发送到邮箱 |
+1 赞 0
收藏
评论 0
| 转发至：

本文由翊翊所思转载自RENESAS Blogs，原文标题为:Flexible Interface of the ZSSC3241 Enables Bridge as Temperature Sensor，本站所有转载文章系出于传递更多信息之目的，且明确注明来源，不希望被转载的媒体或个人可与我们联系，我们将立即进行删除处理。

全部评论（0）

暂无评论

IDT的传感器信号调节器IC，能为传感器模块提供性能、测试和校准过程优势

瑞萨旗下的IDT传感器信号调节器IC可提供可编程的高精度、宽增益量化功能，再加上功能强大的高位数字纠正和线性算法，有助于传感器接口的设计和生产。IDT提供广泛系列的电阻式和电容式SSC IC，其高度精准的一次性通过校准操作，可实现低成本的高精度传感系统设计。

原厂动态发布时间 : 2019-05-07

瑞萨电子集成式高精度电阻式/电容式SSC辅助客户轻松构建智能传感器解决方案，严苛工作环境中仍能稳定运行

瑞萨电子（Renesas）提供广泛应用的电阻式和电容式传感器信号调节器 (SSC) 产品组合，辅助客户能够轻松构建智能的传感器解决方案。这些用于传感器的集成式、高精度、可靠性和稳定的信号调理电路可以在要求严苛的工业级、汽车级和消费级产品里长期稳定运行。

原厂动态发布时间 : 2021-11-09

IO-Link Helping Make Sense of the World——Renesas‘s IO-Link Slave Sensor Solution

Renesas‘s IO-Link Slave Sensor Solution winning combination showcases two examples of a resistor bridge type sensor with two different slave PHY that can be used depending on users’ system requirements.

原厂动态发布时间 : 2021-12-03

SEMITEC（石塚）定制传感器（NTC热敏电阻组件）选型指南

目录- Basic thermistor characteristics & application circuit example OA Equipment's sensor Automotive sensor Medical sensor Home Appliances' sensor Industrial Equipment's sensor Standard Assembly Product

型号- 103AT-11,203AT-11,EC2F503A2-70456,ED5F103A2-ASSY-4,EC2F103A2-40113-600AY,EC2F203A2-70030,EC2F104A2-60109,EC2F102A2-71014,EC2F202A2-71048,103JT-025-600AY,202AT-11,502AT-11,EC2F103A2-40113,102AT-11,EC2F103A2-XXXXX,EC2F502A2-40103,104AT-4-ASSY-5,XXXAT-11,103AT-2-34119,EC1K103A2-17E011,EF1M493NT-ASSY-1/2

选型指南 - SEMITEC - 2019-08-30 PDF 英文下载

NOVOSENSE NST1002 Temperature Sensor Facilitates Accurate CGM Measurement with Glucose Monitoring Black Technology

The NOVOSENSE NST1002 is a high-precision, low-power temperature sensor that can sense changes in ambient temperature or body surface temperature in real-time and adjust the algorithm accordingly to make glucose monitoring more accurate.

应用方案发布时间 : 2023-06-16

SLKOR SLT3535-NX Temperature Sensor: Small and Accurate, Boosting Smart Device Applications

The SLT3535-NX temperature sensor has a wide range of applications. It can be used in smart wearable devices, smartphones, industrial equipment temperature monitoring, non-contact infrared temperature measurement for ear and forehead, household appliances, and intelligent temperature sensing and control.

产品发布时间 : 2023-12-27

Semitec Developed Ultra-Accurately Measuring Active Temperature Sensor, 15 Times More Accurate and 10 Times Faster

Semitec‘s previous highest performance temperature sensor takes 3.3s to reach 34.8℃ (thermal equilibrium) and still does not quite reach the final object temperature. However, the Ultra-accurate Active Measurement Temperature Sensor takes only 0.3s to reach 35℃.

产品发布时间 : 2023-08-08

Renesas（瑞萨）汽车产品选型指南

目录- 汽车微控制器汽车信息系统 - 微控制器微控制器工具片上系统片上系统工具电源电压产品分立式电源产品电机驱动器可配置的混合信号IC 触觉驱动器汽车传感器解决方案无线电源产品时钟和时序解决方案视频和显示控制器光电耦合器零件编号系统一般信息介绍

型号- R-CAR V3X,Y-RH850-P1X-144PIN-PB-T1-V2,NP60N04VUK,Y-RH850-F1X-100PIN-PB-T1-V3,Y-RH850-F1X-233PIN-PB-T2-V1,NP45N06PUK,NP75N04YUK,NP75N04YUG,R-CAR V4H,NP35N04YUG,R8A779M8,R8A779M7,R8A779M0,NP16N06YLL,R8A779M2,R8A779M1,R8A779M4,R-CAR GEN4,R8A779M3,R-CAR V4X,R-CAR E3E,R8A779M6,R8A779M5,DA9131-A,5P49V60,RL78/F1X,R-CAR M3E-2G,R8A779MB,DA9214-AT,DA7280-A,Y-R-CAR-M3N-SIP-BOARD-SKT-ES20,R5F109LD,R5F109LC,R5F109LB,RH850/D1M1A,R5F109LA,R-CAR D3,SLG46857-A,R5F109LE,NP36P04SDG,Y-RH850-F1X-324PIN-PB-T1-V1,ISL78714,Y-RCAR-V4H-WHITEHAWK-BRD-WS10,DA9215-AT,RTE0T00020KCE00000RE2,Y-ASK-RL78F14-V2,R-CAR D3E,R8A77980A,RAJ2800024H11HPF,R7F702300EABA,DA9132-A,NP160N055TUK,R-CAR S4-4,Y-ASK-RL78F15-V2,ZSC31150,NP45N06VDK,RL78/F13-CAN,DA9213-AT,RH850/ F1K,DA9141-A,NP50P04SDG,Y-QB-V850E2-EE,R-CAR S4-8,Y-RH850-P1XC-404PIN-PB-T1-V2,RH850/F1KM-S1,RH850/F1KM-S4,Y-RH850-X2X-MB-T1-V1,RTE0T00001FWREA000R,RTE7702200EAB00000J,Y-ASK-RH850F1KM-S1-V3,Y-RH850-D1L2-PB-TET-V1,R7F702300EBBG,R7F702300EBBB,RTP8A77980ASKB-0CW0SA001#WS,DA9224-AT,R5F10BAG,R5F10BAF,R5F10BAE,R5F10BAD,R7F702011EABG,R5F10BAC,NP29N06QUK,RTP0RC77995SEB0010S,NP89N04PUK,R-CAR H3,RH850/F1KH-D8,R7F702011EABA,RTP0RC7796SIPB0012SS5A,DA9142-A,NP20P06YLG,Y-RH850-E2X-292PIN-PB-T1-V2,NP179N04TUK,R5F10BBG,R5F10BBF,EWRL78,R5F10BBE,R5F10BBD,R5F10BBC,Y-RH850-E2X-373PIN-PB-T1-V3,R8A779FXLAX0BG,NP75P04YLG,RL78/F12,RL78/F13,RL78/F14,DA9130-A,RL78/F15,R-CAR V3M,R5F10AAA,R5F10DGD,Y-QB-R5F113TL-TB-V2,R5F10DGC,Y-R-CAR-V3M-BOARD-DEV-ES20,R-CAR V3H,RBA250N04AHPF-4UA01,NP30N06QDK,TW8832S,R5F10AAE,R5F10AAD,Y-ASK-RCAR-M3W-8GB-WS30,R5F10AAC,NP35N04YLG,R5F10DGE,R7F701412,Y-ASK-RCAR-V3H-WS11,R7F701652,R7F701410,R7F701653,R7F701411,Y-RH850-P1X-100PIN-PB-T1-V2,R7F701650,R7F701651,Y-RH850-F1X-144PIN-PB-T1-V3,R7F701649,R7F701408,R7F701647,R7F701648,R7F701645,R7F701403,NP15P06SLG,R7F701646,ISL79988,R5F10ABA,ISL79987,Y-QB-RL78D1A2-ZZZ-EE,NP90N04VUK,Y-RH850-D1M2H-PB-DEV-V1,R5F10ABE,R5F10ABD,QB-R5F109GE-TB,RBA160N04AHPF-4UA01,R5F10ABC,R7F701421,R7F701422,ΜPD166033,ΜPD166032,RAA279971,ΜPD166034,RAA279972,R7F701417,R-CAR M3,RV1S2752Q,R5F10CGD,R5F10CGC,R5F10CGB,Y-RH850-U2A-144PIN-PB-T1-V1,Y-QB-RL78F14-ZZZ-EE,Y-SBEV-RCAR-KF-M06,SLG46827-A,RH850/C1M-A2,RH850/C1M-A1,R7F702012AEABG,RTE7701460EPA00000R,R5F10PAE,RAA2S4251B,R5F10PAD,R7F701623,R-CAR GEN4 系列,R7F702012AEABA,ZSSC4132,Y-R-CAR-H3-8GB-BOARD-SKT-WS30,NP109N055PUK,ISL78434,R7F701401,R7F701644,R7F701402,Y-ASK-RCAR-V3H-WS21,DA9223-AT,NP90N06VLK,R5F10PBE,R5F10PBD,R5F10BGF,Y-RCAR-V3H-CONDOR-I-BRD-WS20,R5F10BGE,SLG46880-A,R5F10BGD,Y-RH850-X1X-MB-T1-V1,R5F10BGC,R8A77970,ISL78424,ZSSC3154,DA9062-A,ISL76671,R5F10BGG,NP75N055YUK,NP89N055PUK,NP20P04SLG,R5F113GL,RH850/P1L-C,R5F113GK,ZSSC4151,R5F10DLE,R5F10DLD,R5F10968,R-CAR M3NE-2G,ISL78610,R5F1096E,R5F1096D,R5F1096C,R5F1096B,R5F1096A,Y-ASK-RCAR-V3M-WS20-REV2,RTP0RC77951SKBX010SA03,P9149W,R5F10AGG,R5F10DMJ,QB-R5F10BMG-TB,R5F10AGF,ZSSC3170,R5F10AGE,R5F10AGD,R5F10DMG,R5F10AGC,R5F10DMF,Y-RH850-U2A-292PIN-PB-T1-V2,R5F10DME,R5F10AGA,R5F10DMD,ISL78600,RL78/F13-LIN,Y-R-CAR-D3-BOARD-DEV-WS11,DA9063-A,R- CAR H3NE-1.7G,R7F701710,RH850/P1M-C,RH850/P1M-E,DA9063L-A,QB-R5F10PPJ-TB,Y-RH850-X1X-MB-T2-V1,NP50P06KDG,ZSSC4175,R7F701708,R5F10CLD,R7F701709,NP75N04VUK,5P35023,5P35021,Y-ASK-RCAR-V3M-WS20,NP15P04SLG,R7F701278EAFP,Y-RH850-F1X-048PIN-PB-T1-V1,ZSSC4169,NP100P04PDG,R7F701715,R7F701714,R7F701711,Y-RH850-P1XC-292PIN-PB-T1-V2,ZSSC4161,ZSSC4162,ISL76683,Y-QB-RL78F15-ZZZ-EE,ZSSC4165,R5F10CME,R5F10CMD,R7F701371,R7F701372,NP60N04VDK,R-CAR V4X系列,RH850/X2X,Y-RH850-TFT-EXT-BRD,RH850/F1K,R5F10PGH,R7F701379,R5F10PGG,R5F10PGF,R7F701377,R5F10PGE,R7F701378,Y-RH850-E2X-40NM-EMU-ADAPTER-REV2,R5F10PGD,R7F701375,NP100P06PDG,R7F701376,DA9214-A,R7F701373,R7F701374,R5F10BLC,R5F10DPE,TW8819,R5F10PGJ,SLG46620-A,F1KM-S4,R5F10DPL,R5F10DPK,R5F10DPJ,R5F10BLG,R5F10BLF,R5F10BLE,R5F10DPG,R5F10BLD,R5F10DPF,R7F701382,R7F701383,R7F701380,R7F701381,ISL78365,R-CAR M3E,NP16N06QLK,R5F113LK,R7F701388,R7F701389,R5F10TPJ,R7F701386,R7F701384,R7F701385,NP90N04VLK,R5F113LL,TW8809,RTP8J77961ASKB0SK0SA05A,R5F10BMG,R5F10BMF,R5F10BME,R-CAR M3N,NP33N06YDG,5PB1110,RTE0T0002LKCE00000R,Y-ASK-RCAR-H3-8GB-WS30,R7F701275EABG,Y-BLDC-RH850F1KM-S1-V2,R5F113ML,R5F113MK,R7F701597,NP90N06VDK,NP50P03YDG,DA9215-A,ΜPD166031A,R5F10ALD,R5F10ALC,Y-RH850-F1X-176PIN-PB-T1-V4,NP20P06SLG,NP30N04QUK,TW8832,R5F10ALG,TW8836,R5F10ALF,R5F10ALE,NP83P04PDG,TW8834,DA9141-AT,RH850/X1X,RAA271005,RAJ2800044H12HPF,F1KM-S1,RAA271001,RAA271000,5PB1104,NP36P04KDG,R5F10AME,R-CAR S4,DA9130-AT,RH850/U2A16,RTP0RC77990SEB0020SA00,NP100N04PUK,RH850,Y-RH850-P1XC-144PIN-PB-T1-V1,R5F10DSL,R5F10DSK,R5F10AMG,R5F10DSJ,TW8824,R5F10AMF,TW8823,R7F701690,R7F701691,RH850/ F1KH-D8,DA9142-AT,RTP0RC77965SIPB012S-S,RV1S9184Q,R7F701694,R7F701695,R7F701692,R7F701693,RAA2S4253B,R7F701689,RH850/P1H-C,IPS2550DE1R,NP45N06VUK,NP50P04KDG,R5F10PLE,R5F113PG,R7F701580,R7F701581,DA9063L-AT,Y-R-CAR-M3W-8GB-BOARD-SKT-WS30,R-CAR GEN3E 系列,RH850/P1X-C,R7F701586,R5F10PLJ,R5F113PL,R7F701587,R5F113PK,R-CAR V3X 系列,NP36P06KDG,R5F10PLH,R5F113PJ,DA9224-A,R5F10PLG,R7

选型指南 - RENESAS - 版本 5.0-1 - 2022.04 PDF 中文下载

【经验】瑞萨MPU RZ/T1使用SSC生成EtherCAT CiA402协议栈方法

瑞萨MPU RZ/T1支持EtherCAT网络设计，如何使用协议栈工具生成相对应的EtherCAT从机栈代码呢，本文主要就Beckhoff工具生成EtherCAT CiA402协议栈方法做相关介绍。

设计经验发布时间 : 2021-12-26

ZSSC3241 Sensor Signal Conditioner IC for Resistive Sensors Datasheet

型号- ZSSC3241DI5B,ZSSC3241DL3W,ZSSC3241DI1C,ZSSC3241KIT,ZSSC3241DL1B,ZSSC3241DL1C,ZSSC3241DI5C,ZSSC3241DL5B,ZSSC3241DI1B,ZSSC3241DL5C,ZSSC3241DL3R,ZSSC3241DI3W,ZSSC3241,ZSSC3241DI3R

数据手册 - RENESAS - Sep.19.23 PDF 英文下载查看更多版本

【产品】高精度SENT输出接口的汽车电阻桥式传感器信号调节器ZSSC4169

传感器信号调节器 (SSC) ZSSC4169是IDT（Renesas收购）推出的一款可实现信号高精度放大和差分电桥传感器信号校正的CMOS集成电路。其具有最大200的模拟预放大，该产品可调节满足几乎所有桥式传感器类型。通过一个16位RISC微控制器可完成偏置、灵敏度、温漂和非线性的数字补偿。校准系数和配置数据存储在ZSCC4169非易失存储器（NVM）中，在汽车应用中非常可靠。

新产品发布时间 : 2019-05-21

RENESAS（瑞萨电子）传感器信号调理器产品介绍

描述- Automotive & IndustrialSensor Signal Conditioner ---SSC

型号- ZSC31014,ZSC31015,ZSC31050,ZSC31150,ZSC31010,ZSSC3123,ZSSC3224,ZSSC3026,ZSSC324X,4162D,4132D,ZSSC4151,ZSSC4132,ZSSC30X6,ZSSC4175,ZSSC3122,ZSSC3135,ZSSC4169,ZSSC3036,ZSSC3136,ZSSC323X,ZSSC3018,ZSSC3138,ZSSC3XYZ,ZSSC3218,4169D,ZSSC4161,ZSSC3170,4151C,4161B,4175D,4165D,ZSSC4162,ZSSC3131,ZSSC3230,ZSSC4165,ZSSC41XY,ZSSC3154

商品及供应商介绍 - RENESAS - 2019年4月 PDF 英文下载

EU185 UNIVERSAL NFC CHARGER

型号- HS40XX,RAA2142504GSP#HA0,RAA214220,ISL28005FH50Z-T7,RA4M2,HS4003,HS4004,ISL28005-50,HS4001,HS4002,ISL28023FR60Z-T7A,ISL28022FUZ-T7A,HS4000-EVK,R7FA4M2AB3CFP#AA0,ISL91107IIAZ-T7A,ISL91107IINZ-T7A,RAA214250,HS4011,R7FA4M2XB3CNE,PTX130W,PTX130WDQ56D7,HS401X,ISL28005,ISL28005-20,HS4014,ISL28025,ISL28022,HS4012,ISL28023,HS4013,ISL91107IIAZ-T,R7FA4M2XB3CFL,R7FA4M2XB3CFM,R7FA4M2XB3CFP,ISL28025FI60Z-T7A,ISL28022FRZ,ISL91107,ISL28005-100

应用及方案 - RENESAS - V1.1 - SEPTEMBER 2023 PDF 英文下载

汽车成功产品组合

型号- ISL78010,RH850/F1L,R-CAR V3X,DA9214-A,RBA250N10,RL78/F23,RL78/F24,SLG46620-A,NP75N04YUK,R-CAR V4H,ZSSC417X,DA16600MOD,RXRAA279972,R-CAR E3,RH850/F1X,NP90N04VLK,5P49V60,RL78/F1X,DA7280-A,R-CAR M3N,RH850/D1M1A,ANL3,U2A16,RH850/P1X,ANL2,R-CAR D SERIES,R-CAR H SERIES,RL78 SERIES,NP20P06SLG,UPD166031A,RH850 / F1X,RH850/C,ISL78714,ISL78264,RBA160N04AHPF,RAA271005,RAA271000,R-CAR S4,RH850/U2A16,TXRAA279971,SERIES,NP100N04PUK,RH850,UPD166027,RL78/15,RL78/G23-64P,RAJ2800034,RH850/P1M,ISL78215,RH850/F1KM-S1,HS4011,5P49V60A,ΜPC842A,DA7280,DA9224-A,RAJ2800024,PR-INV06500780-FB,RTKA279971ZB0000BU,RTK7RLG230CLG000BJ,RAA278840,RAA270005KFP,RAA278842,ISL78206,ISL78208,ISL78322,RL78,ISL78444,TW8847,TW8846,RAA270005,NP109N04PUK,ISL78233,ISL1208,NP89N04PUK,R-CAR H3,RAA270000,R-CAR E SERIES,DA9213-A,R-CAR M SERIES,RAA279940,NP89N04PDK,NP50N04YUK,ISL78234,ISL78235,ISL78236,UPD166027T1J,RH850 / D1M1A,RAA270000KFT,R-CAR V3U,DA728X,RAJ2800044,RL78/F13,RL78/F14,R-CAR V3M,IPS2550,R-CAR V3H,P9261-3C,TW884X,ISL78224,UPD166033T1U,ISL78226,RH850 / F1KM-S1,RJQ7031,NP75N04YLG,ISL78714XB-EVKIT1Z,NP90N04VDK,ISL78419,RH850/C系列,RBA250N10CHPF-4UA02,RTK7F124FGS00000BJ,DA9063L,TW99XX,ISL799XX,RH850 U2X,NP90N04VUK,DA9063A,NP75N04YUKX6,XLH335006.005284K,RL78 / F1X,ISL78083,R-CAR S SERIES,DA14531,ANL3 SERIES,RAA279971,RAA279972,R-CAR M3,RV1S2752Q,RAA2788XX,TW88XX,RAA270205,ISL78310,RH850/D1M1-A,RA A271000,DA9223A,SLG46827-A,ISL81601,RH850/C1M-A2,RH850/C1M-A1,RH850-P1M,RAA2799XX,RJU7032,RH850/CM-AX,ZSSC4132,ISL78434,ISL78420,DA9224A,DA9223-A,RAA271082,RH850/F1KM,RH850/C1X,9FGV0841,ISL78307,ISL78301,ISL78424,NP180N04TUK,ISL78171,RBA250N04AHPF,RH850/C1M-AX,RH850/U2X,ZMOD4510,ISL78714BMS5XBEKIT1Z,R2A25110,IW7039-A,NP110N04PUK,ZSSC3170,RH850F1KM-S1,DA9063-A,RTK7F70169S00000BJ,R-CAR S,RAA271050,DA16200,RH850/P1M-E,RH850/U2AX,UPD166033,UPD166034,SLG46855-A,RAA2778842,ISL12022,ISL78434X3,RAA2778843,RAA2778840,UPD166031,UPD166032,R-CARS4,R-CAR V SERIES,5P35023,5P35021,ZMOD4410,NP15P04SLG,UPC842AMP,RAA271041,ANL2 SERIES,RH850/E1X,RH850/U2BX,UPD166029,ISL76683,RH850/U2A,ZSSC4165

商品及供应商介绍 - RENESAS - 2023.02 PDF 中文下载