【技术】延长铝电解电容使用寿命需要注意的因素

时间： 2017-12-14 来源：世强作者：honglei

代理服务

技术支持

批量订货

铝电解电容器的正极、负极引出的电极和外壳都是高纯铝，铝电解电容的介质是在正极表面形成Al2O3薄膜，如下图1所示。该氧化铝是在蚀刻过程中形成的，真正的负极是电解液，工作时相当于一个电解槽，只不过正极表面因氧化而不再发生化学反应，理论上电流是零，由于电极与电解液杂质的影响，会引起微小的漏电流。从现象上看，铝电解电容器失效现象和失效模式有：电解液干涸、压力释放装置动作、短路、开路、漏电流过大等。

图1：蚀刻铝箔的显微视图

一、电解液干涸

电解液干涸除去受电解液自然挥发影响，主要受到漏电流（IL）所引起的电化学效应造成的电解液消耗，电解液干涸的时间就是铝电解电容的寿命，解决好铝电解电容器的漏电流的影响因素可以延长其使用寿命。

理论与实践都表明，铝电解电容器漏电流大小与以下因素有关：

1、漏电流大小与施加的直流电压"U"有关，电压越大漏电流越大。耐压为400V的铝电解电容在额定电压下的漏电流大约是90%额定电压下漏电流的5倍。

2、与施加直流电压的时间"t"有关，时间越长漏电流越小，可参考如下图2所示。

图2：典型漏电流（IL）随时间变化曲线

3、与铝电解电容所处的环境温度（T）有关，环境温度越高漏电流越大。环境温度25℃时的漏电流仅是85℃时漏电流的不到1/10，参考如下图3所示；

图3：典型漏电流（IL）随温度变化曲线

4、与介质氧化铝膜的品质和形成工艺等因素有关。

5、与铝电解电容的容量（C）有关，容量越大漏电流越大。

其实，铝电解电容器的使用寿命可通过环境温度计算出其使用寿命，

公式为：USEFUL LIFETIME = LOPMAX x 2 ^{(Tmax+10-Tc) /10}；

式中，用小时数表示的有效生命周期。

LOPMAX = 额定最高工作温度下的使用寿命（比如：85℃ 下10000 小时）

T max = 电容器实际工作温度（比如：K01 型号产品温度为85℃）

T c = 内部芯线温度 = 电容器内部热点（℃）

举例：

对于内部芯线温度为55.43℃ 的电容器，在45℃ 环境温度下的预期寿命计算如下：

有效生命周期

= 10000x2 ^{（85+10-55.43） /10}

= 10000x2^3.956

= 155194 小时

漏电流（IL）在出厂时一般均会在datasheet里标注出来，以KENDEIL K76系列铝电解电容为例，其漏电流IL max=K*Cr Vr + 4μA（Cr），K=0.006，参考如下图4所示，这里说明下，该漏电流IL标定的值是在20℃，额定电压下，5分钟后测量得到的，不同的厂家测试标准可能不一样的，一般是1分钟后测量得到的，而行业里通常是0.03CV，而Kendeil在1分钟后测量得到的值大约在0.015CV，可以从图1中推算出来，IL≈20/8*0.006=0.015CV。

图4：Kendeil K76系列铝电解电容漏电流标定值

二、压力释放装置动作

铝电解电容器中电解液由于内部高温沸腾的气体或电化学过程产生的气体而引起铝电解电容内部高压气体累计，当达到一定的量时，会造成铝电解电容器内部气压过高爆炸。为消除铝电解电容器的爆炸，直径8mm以上的铝电解电容器均设置了压力释放装置，在其爆炸动作之前及时泄放内部气体。不过，当压力释放装置动作时，也宣告着铝电解电容器失效而寿命终结。

铝电解电容器产生压力释放动作主要受两方面影响：环境温度过高（如附近有发热元件、所处高温工作环境）、芯包温度过高，其中芯包温度过高的根本原因是过高的纹波电流在电解电容ESR的过渡消耗下产生过量的热，过量的热进而蒸腾电解液产生大量气体导致，这里不再详细分析。

结论：

想要获得更长的使用寿命铝电解电容，一定要注意温度、施加电压、低ESR、低IL（漏电流）等因素，除去ESR和IL是铝电解电容自身的硬指标外，内外的温度、过压的保护等均需要考虑。

上面主要是针对铝电解电容器的漏电流、压力释放装置影响其寿命做分享，至于其他技术参数及选型部分，可以参考下世强电商发布的《电解电容选型，这些参数是你必须知道的》这篇文章，里面有详细的描述，如果您感兴趣记得收藏和点赞哦，感谢！有问题请留言或电话联系世强400-887-3266。想了解更多关于电解电容的生产工艺、选型可以点击如下链接下载资料：https://www.sekorm.com/doc/previewDoc?docId=65947

发送到邮箱 |
+1 赞 0
收藏
评论 181
| 转发至：

本网站所有内容禁止转载，否则追究法律责任！

全部评论（181）

用户_8353 Lv8 2019-03-08

学习了
大新 Lv7. 资深专家 2018-11-22

好文章
godfather161210 Lv6. 高级专家 2018-11-20

学习了
Tiger Lv7. 资深专家 2018-11-15

不错
小胖 Lv7. 资深专家 2018-11-13

值得学习

DY Lv4. 资深工程师 2018-11-13

学习学习
用户24428459 Lv6. 高级专家 2018-11-12

了解一下
宇宙星神 Lv6. 高级专家 2018-11-11

学习下
郭攻城狮 Lv7. 资深专家 2018-11-10

学习下看看
KDS Lv7. 资深专家 2018-11-08

值得学习！!

展开更多评论

【技术】算法大揭秘影响铝电解电容寿命的原因

致铝电解电容寿命缩短的主要因素是周围的温度和纹波电流。本文分别探讨周围温度和纹波电流对铝电解电容寿命的影响以及其算法。此外，介绍了Kendeil的铝电解电容，其电容容量最高达47万μF，纹波电流高达100A，在85℃工作温度下，寿命长达10万小时。

2017-04-18 - 原厂动态代理服务技术支持批量订货

Nippon Chemi-Con为音频设备应用提供多种优质铝电解电容

针对家庭影院，高端音频系统和PC（个人用途主板）等音频设备，Nippon Chemi-Con提供了表面贴装型、径向引线型、基板自立型等不同的铝电解电容器产品满足音频应用的需求。

2020-09-16 - 原厂动态代理服务技术支持批量订货

铝电解电容选型：容量高达680000μF，产量世界第一的黑金刚铝电解电容

Nippon Chemi-Con黑金刚是铝电解电容器的顶级制造商，全球市场占有率位列首位。黑金刚铝电解电容其铝箔表面积增加，使得器件体积小型化、大容量（0.1～680000μF）。

2018-08-21 - 原厂动态代理服务技术支持批量订货

【选型】Kendeil 铝电解电容选型指南（中文）

型号- K04350153__M0L220,K05100102_PM0C030,K42400152__M0H105,K02063222__M0E060,K02063473__M0J143,K22350682__M0J214,K05025472_PM0C030,K13125600000000B2,K41450682__M0J214,K42100222__M0E060,K02400471__M0G079,K06450331_PM0E040,K42025153__M0E060,K42400103__M0L220,K76250761_PM0D035,K41075472__M0E060,K13125200000002B2,K06500331_PM0E050,K91450332__M0J105,K75400122_PM0E060,K41016154__M0H105,K72450222__M0G105,K11400203__M0J240,K21450332__M0L098,K05200221_PM0B030,K01016473__M0G079,K07160103__M0G115,K76450681_PM0E040,K21350152__M0G079,K41075103__M0G079,K71400303__M0L220,K02200681__M0E060,K41400222__M0J105,K04500682__M0J214,K71450472__M0H105,K06050223_PM0F050,K22420682__M0J214,K05050223_PM0F050,K42250153__M0J214,K05450331_PM0E050,K11350203__M0J240,K06050103_PM0D040,K22400682__M0J214,K03400222__M0J143,K42063153__M0G105,K03500222__M0L145,K04500392__M0J143,K75450222_PM0V077,K76350921_PM0D050,K91400222__M0G105,K05040472_PM0D025,K03450152__M0J105,K61080423__M0J143,K95420681_PM0E050,K01200681__M0E060,K91420222__M0G105,K42400222__M0J105,K05400821_PM0E060,K05450331_PM0E040,K95400681_PM0E050,K01450681__M0G079,K05500181_PM0D050,K03500152__M0J143,K13320050000002B2,K41500102__M0G079,K55450561_PM0E060,K02063473__M0J105,K13125800000001B2,K02450152__M0J105,K76350122_PM0E045,K07160333__M0J143,K42063333__M0J105,K07200143__M0H130,K13125315000002B2,K76200681_PM0C035,K76400242_PM0N077,K76350881_PM0D045,K01025333__M0E079,K11450203__M0L220,K41100473__M0J143,K76350242_PM0N060,K42016154__M0H105,K05200102_PM0E030,K75450182_PM0V060,K72450822__M0J143,K22450103__M0L220,K41400152__M0H105,K06500152_PM0N097,K02500102__HM0G105,K06200221_PM0B030,K42040154__M0J143,K11400233__M0L240,K91450332__M0J143,K41025103__M0E060,K07160822__M0G105,K21400152__M0G079,K21420152__M0G079,K13320031000002B2,K91450152__M0G105,K75350122_PM0E050,K13250040000001B2,K42350222__M0J105,K75420251_PM0C035,K42025103__M0E060,K75400511_PM0E030,K95450221_PM0D030,K05450471_PM0E050,K42100682__M0G105,K01200332__M0H105,K91400332__M0H105,K01075103__M0G079,K21400332__M0J098,K42350152__M0H105,K72350133__M0J143,K95350102_PM0E060,K21420332__M0J098,K06100102_PM0C030,K91420332__M0H105,K95350391_PM0D035,K95350681_PM0E040,K06550101_PM0D030,K85450391_PM0E045,K06200102_PM0E040,K41050333__M0G105,K22350222__M0H105,K07250682__M0G130,K95420821_PM0E060,K01050473__M0G105,K76250102_PM0E035,K03400102__M0H105,K15420102_PM0F060,K41200472__M0G105,K72350292__M0G079,K21450472__M0L098,K04450222__M0H105,K85400151_PM0C030,K71450682__M0J105,K76450272_PM0N105,K76400442_PM0V105,K26400152_PM0N060,K95350471_PM0C050,K02400222__M0J105,K02450682__M0J214,K06500221_PM0D050,K92450102__M0G105,K76450102_PM0E060,K02040683__M0J105,K21400332__M0J079,K02100682__M0G105,K01016155__M0L220,K42040104__M0J105,K02100222__M0E060,K11400163__M0J240,K02400152__M0H105,K22350123__M0L220,K06550561_PM0F077,K01075472__M0E060,K03450122__M0H105,K06400821_PM0E060,K42400471__M0G079,K02016154__M0H105,K26400202_PM0F105,K85350391_PM0C050,K16420102_PM0F060,K85420331_PM0C055,K95420391_PM0D040,K01016154__M0H105,K42040473__M0H105,K03475561__M0G105,K72420103__M0L105,K16450152_PM0V060,K15450152_PM0V077,K91450681__M0G079,K76420122_PM0E060,K41016473__M0G079,K75450272_PM0N105,K01160333__M0J214,K42040104__M0J143,K06600271_PM0F050,K01040223__M0E079,K01400222__M0J105,K76450202_PM0F097,K41040473__M0H105,K91450102__M0G105,K05200471_PM0C030,K71350682__M0H105,K85420391_PM0C055,K55450561_PM0E050,K25400152_PM0N077,K75450102_PM0E060,K95450271_PM0D040,K76250152_PM0E050,K85400271_PM0E030,K01350222__M0G105,K04400152__M0H105,K76450391_PM0D035,K02016224__M0J105,K04400332__M0H105,K75420352_PM0V105,K01100222__M0E060,K01350681__M0E079,K15420152_PM0F097,K75450391_PM0D040,K76200821_PM0C040,K41450822__M0J214,K01400153__M0L220,K05050103_PM0D040,K02025153__M0E060,K92420471__M0G079,K22420222__M0H105,K42100333__M0J143,K07250392__M0G096,K76250252_PM0F060,K13125250000002B2,K01250471__M0E060,K22400392__M0J105,K41250152__M0G079,K21400392__M0J105,K41500682__M0J214,K71400392__M0G105,K01160152__M0G079,K04600222__HM0J143,K76420561_PM0E035,K95350821_PM0E050,K01025153__M0E060,K91400103__M0J143,K95450471_PM0E050,K76350292_PM0N077,K41450102__M0G079,K42063222__M0E060,K04400222__M0J105,K01400332__M0H105,K21450122__M0G079,K06200471_PM0C030,K01016334__M0H105,K02160152__M0G079,K75420561_PM0E035,K01063473__M0G105,K25400272_PM0V105,K01025154__M0J105,K01450152__M0G105,K75450332_PM0V105,K16420152_PM0F097,K76200332_PM0F060,K07250123__M0H143,K11400153__M0J214,K02450331__M0E079,K01075153__M0G105,K02450822__M0J214,K06016153_PM0D030,K16420222_PM0V105,K01050683__M0H105,K06400681_PM0E050,K41350332__M0H105,K91420682__M0J143,K16420182_PM0V077,K95420181_PM0C030,K75450221_PM0C035,K75350821_PM0D050,K95400181_PM0C030,K07250123__M0H130,K25450122_PM0N077,K41016334__M0H105,K71420332__M0G105,K21420103__M0J214,K25420272_PM0V105,K22400332__M0J105,K75400821_PM0D060,K16400152_PM0F077,K75450821_PM0E050,K15400182_PM0V077,K02040104__M0J143,K01100103__M0H105,K02200222__M0G105,K02450102__M0G105,K76200182_PM0E040,K02100153__M0H105,K05063682_PM

2016年07月26日 - KENDEIL - 选型指南代理服务技术支持批量订货

REACH法规符合性K01、K02、K03、K04、K05、K06、K07、K11、K13、K15、K16、K21、K22、K25、K26、K41、K42、K55、K61

描述- Kendeil srl作为铝电解电容制造商，声明其产品K01至K61型号的电容不含任何禁止物质，符合REACH法规和更新后的SVHC候选清单（截至2014年6月16日）。REACH法规（1907/2006）自2007年6月1日起生效，旨在规范欧洲市场上化学品的提供，并规定禁止使用某些物质以改善环境、健康和安全性能。

型号- K61,K42,K41,K11,K22,K55,K21,K02,K13,K01,K04,K15,K26,K03,K25,K06,K05,K16,K07

1 JULY 2014 - KENDEIL - 测试报告代理服务技术支持批量订货

K76型-40℃+85℃5000h

描述- 该资料详细介绍了K76系列铝电解电容器的技术规格和应用。资料涵盖了产品的设计优化、尺寸规格、电气特性、应用领域、温度范围、寿命测试、储存条件以及标记信息等。

型号- K76420172_PM0N060,K76200561_PM0C030,K76400561_PM0D040,K76200332_PM0F060,K76400202_PM0N060,K76450561_PM0D045,K76450681_PM0E050,K76420561_PM0D045,K76250761_PM0D035,K76350182_PM0F060,K76250761_PM0D040,K76400681_PM0E040,K76420681_PM0E045,K76350561_PM0D035,K76350681_PM0E040,K76500561_PM0E050,K76450681_PM0E040,K76500681_PM0E055,K76420381_PM0E040,K76400681_PM0E035,K054504710PM0E050,K76400781_PM0E040,K76200182_PM0E040,K76350472_PM0V105,K76350561_PM0D040,K76500681_PM0E060,K76450331_PM0D040,K76200122_PM0C050,K76400222_PM0N077,K76400681_PM0D050,K76350921_PM0D050,K76420332_PM0V105,K76,K76420681_PM0D050,K76400332_PM0V105,K76350272_PM0F097,K76350331_PM0C040,K76450242_PM0V077,K76420291_PM0C040,K76250122_PM0D050,K76350122_PM0E045,K76350821_PM0D050,K76400332_PM0N105,K76200681_PM0C035,K76200102_PM0C050,K76400242_PM0N077,K76350881_PM0D045,K76500181_PM0C040,K76350242_PM0N060,K76420291_PM0C035,K76350331_PM0C030,K76450332_PM0V105,K76350442_PM0N105,K76200102_PM0C045,K76450152_PM0F060,K76350621_PM0D035,K76450821_PM0E050,K76350821_PM0D045,K76400221_PM0C030,K76450751_PM0E050,K76420921_PM0E050,K76250821_PM0D040,K76500821_PM0E060,K76450331_PM0D030,K76450561_PM0E040,K76350821_PM0E040,K76200102_PM0D040,K76500471_PM0D050,K76450751_PM0E045,K76450561_PM0E035,K76350292_PM0V060,K76450202_PM0N077,K76450271_PM0C035,K76200681_PM0C040,K76200102_PM0D035,K76350821_PM0E035,K76450271_PM0C040,K76450621_PM0D050,K76500181_PM0C030,K76450561_PM0D050,K76500222_PM0N105,K76500102_PM0F060,K76350471_PM0D030,K76500182_PM0N097,K76350222_PM0F060,K76250102_PM0E035,K76420272_PM0V077,K76250471_PM0C040,K76200102_PM0E030,K76200272_PM0E060,K76350122_PM0F050,K76400471_PM0D040,K76500471_PM0E040,K76350372_PM0V077,K76350172_PM0E060,K76450471_PM0D040,K76450272_PM0N105,K76400442_PM0V105,K76400172_PM0F060,K76200152_PM0D045,K76350102_PM0E050,K76450362_PM0V105,K76350222_PM0F077,K76350471_PM0D040,K76400102_PM0E060,K76350562_PM0V105,K76250471_PM0C035,K76420102_PM0E060,K76400242_PM0F097,K76250102_PM0D050,K76450102_PM0E060,K76450202_PM0V060,K76200122_PM0E040,K76250222_PM0E060,K76200152_PM0D050,K76420621_PM0E040,K76500331_PM0C050,K76250122_PM0E040,K76400391_PM0D040,K76400102_PM0E050,K76 TYPE,K76400821_PM0E050,K76420821_PM0E050,K76500221_PM0D030,K76250391_PM0C030,K76350521_PM0D030,K76200152_PM0E035,K76400391_PM0D030,K76420521_PM0E030,K76400292_PM0V077,K76450162_PM0N060,K76500122_PM0F077,K76250102_PM0E040,K76400222_PM0V060,K76420821_PM0E045,K76400471_PM0D035,K76250821_PM0E030,K76400122_PM0E060,K76420222_PM0V060,K76200152_PM0E040,K76400821_PM0E045,K76420122_PM0E060,K76420471_PM0D035,K76500331_PM0D040,K76350391_PM0C035,K76350152_PM0F050,K76400681_PM0D045,K76400721_PM0D050,K76450221_PM0C035,K76500152_PM0F097,K76450202_PM0F097,K76500221_PM0C040,K76200122_PM0D040,K76420621_PM0D045,K76250152_PM0E050,K76420521_PM0D040,K76350312_PM0F097,K76450391_PM0D035,K76420331_PM0D030,K76400561_PM0E040,K76420561_PM0E040,K76200821_PM0C040,K76250561_PM0D030,K76350332_PM0V077,K76350142_PM0E050,K76400242_PM0V060,K76200222_PM0E050,K76250102_PM0D045,K76250252_PM0F060,K76420312_PM0N105,K76400561_PM0E030,K76400331_PM0C035,K76450391_PM0D040,K76350681_PM0D040,K76420202_PM0N077,K76200122_PM0E030,K76420561_PM0E035,K76250681_PM0C050,K76450152_PM0N060,K76420621_PM0E035,K76400331_PM0C040,K76420152_PM0F060,K76420222_PM0F097,K76400152_PM0F060,K76350292_PM0N077,K76400721_PM0E050,K76420392_PM0V105,K76200222_PM0E045,K76350391_PM0C040,K76450221_PM0C040,K76350681_PM0D050,K76420561_PM0D050,K76200821_PM0D030,K76420471_PM0E040,K76250681_PM0C045,K76420621_PM0D050,K76350102_PM0E040

2024/6/6 - KENDEIL - 数据手册代理服务技术支持批量订货

Kendeil（肯德尔）金属化聚丙烯直流支撑（DC-Link）薄膜电容器选型指南

目录- K33 TYPE Metallized Polypropylene D.C. Link Capacitors K36 TYPE Metallized Polypropylene D.C. Link Capacitors K37 TYPE Metallized Polypropylene D.C. Link Capacitors

型号- K36800102__K0T125,K36900491__K0Q125,K37111151__K0L065,K36900201__K0J072,K37800221__K0L065,K36111251__K0J120,K36401131__K0U265,K36121182__K0U335,K3350150000K0K152,K36161321__K0T120,K36800421__K0J145,K3318135100K0K152,K36251660__K0Q140,K36900112__K0T150,K36301680__K0Q225,K36201191__K0T125,K36201401__K0U175,K36301121__K0U180,K37800351__K0S064,K36161851__K0U230,K37151111_K0S064,K3311190100K0K152,K36900272__K1U230,K36251351__K0U265,K36600781__K0J140,K37151500_K0L050,K36800352__K0U335,K36111252__K1U335,K36800102__K0R175,K36600152__K0T140,K37141111_K0L076,K37151760_K0L065,K36121331__K0T125,K36111901__K0U125,K36301181__K0U230,K3311110200K0K152,K36251131__K0T140,K37111141__K0L065,K36361600__K0U130,K36111421__K0Q155,K36201151__K0Q175,K36251291__K0U225,K3390013200K0K152,K36111361__K0Q120,K3311180100K0K152,K36800491__K0Q125,K36361420__K0T130,K36800551__K0Q122,K37900151__K0L050,K36401700__K0T230,K36301420__K0Q140,K37400381__K0L065,K36301151__K0T230,K37 TYPE,K37131101_K0L065,K36161151__K0J145,K36201271__K0T175,K36800501__K0T080,K37900351__K0S064,K36161121__K0Q095,K36161151__K0J140,K36600651__K0Q095,K36301101__K0T180,K36121331__K0Q155,K3315150100K0K152,K36361151__K0U265,K36111921__K0T180,K36161171__K0J175,K36251211__K0U180,K36401101__K0U230,K36800501__K0Q122,K3327115100K0K152,K36361111__K0T265,K36600302__K0T230,K37111101__K0L050,K36121501__K0T130,K36111421__K0Q135,K36800751__K0Q175,K36121551__K0T130,K36201201__K0Q225,K37151950_K0L076,K36121221__K0J120,K36301820__K0T180,K36600102__K0Q140,K36800651__K0Q145,K36900152__K0T175,K3313160100K0K152,K36401240__K0Q140,K36900551__K0Q122,K36600651__K0J120,K36800112__K0Q225,K33 TYPE,K36161421__K0T175,K36121251__K0Q120,K36361121__K1U230,K36121251__K0Q125,K36161121__K0J120,K37111191__K0L076,K36111501__K0Q175,K36600112__K0Q140,K37800151__K0L050,K36900202__K0T230,K36111172__K0U230,K36900501__K0T080,K36111401__K0Q145,K37141560_K0L050,K36900102__K0R175,K36800272__K1U230,K36111731__K0T150,K36600481__K0J095,K36900352__K0U335,K37131131_K0L076,K36800471__K0Q122,K36201801__K0U335,K36600202__K0T140,K36900331__K0J117,K3370020200K0K152,K3320130100K0K152,K36121471__K0Q225,K36800331__K0J117,K36600242__K0T175,K36900112__K0Q255,K36111122__K1T230,K36201281__K0T175,K36161471__K0T175,K3313165100K0K152,K36900471__K0Q122,K36900102__K0T125,K37141860_K0L065,K36111331__K0Q120,K36121122__K0U230,K36800201__K0J072,K36111681__K0Q225,K37111231__K0S064,K37141131_K0S064,K36121102__K0T230,K36 TYPE,K36161601__K0T230,K36201601__K0U260,K36900421__K0J147,K37131700_K0L050,K37400601__K0S064,K3322120100K0K152,K36361880__K0T225,K37900221__K0L065,K36161900__K0J095,K36201101__K0Q120,K36301660__K0T120,K36401380__K0Q225,K36121271__K0Q120,K36201371__K0T225,K36201750__K0J120,K36800202__K0T230,K36251211__K0T225,K36111651__K0T125,K36161251__K0Q175,K36900651__K0Q145,K36121421__K0Q175,K36251151__K0T175,K36600821__K0J155,K37400261__K0L050,K36121102__K0U175,K37131101_K0S064,K36900501__K0Q122,K3335110100K0K152,K36121681__K0T180,K36800112__K0T145,K36900751__K0Q175,K36800152__K0T175

02/2020 - KENDEIL - 选型指南 - EDITION 02/2020 代理服务技术支持批量订货

Kendeil 集团是生产大功率逆变器应用电子元器件的领先生产商，有超过37年的设计生产经验。Kendeil集团拥有先进的设备、集成技术和先进的生产工艺，定期不断推出新的工业化产品，以使产品符合国际最高标准的性能和质量。Kendeil的电容产品均达到CECC，DIN，IEC等国际标准，并且通过了ISO9001体系认证。

电容薄膜电容铝电解电容

代理服务线上商城技术资料

K75型-40℃+105℃5000h

描述- 该资料详细介绍了K75系列铝电解电容器的规格、特性、应用领域和编号系统。K75系列以其高微型化设计、耐压、宽温度范围和良好的电气性能而著称，适用于多种专业应用。

型号- K75200102_PM0C045,K75400152_PM0F060,K75200122_PM0D040,K75450332_PM0V105,K75250152_PM0E050,K75400331_PM0C040,K75400561_PM0E040,K75400631_PM0D045,K75420561_PM0E040,K75420651_PM0E040,K75200821_PM0C040,K75420242_PM0V077,K75400392_PM0V105,K75450561_PM0E040,K75200152_PM0E040,K75200681_PM0C035,K75400122_PM0E060,K75450221_PM0C035,K75450182_PM0F097,K75350821_PM0D050,K75350202_PM0F060,K75350152_PM0E060,K75420221_PM0C035,K75500331_PM0D040,K75250561_PM0D030,K75200102_PM0C050,K75500152_PM0N097,K75500561_PM0E060,K75350331_PM0C035,K75350292_PM0F097,K75400681_PM0D050,K75420471_PM0E030,K75200152_PM0E035,K75400292_PM0N105,K75500221_PM0C040,K75500391_PM0D050,K75400631_PM0D050,K75400821_PM0D060,K75450821_PM0E050,K75200122_PM0C050,K75350561_PM0D040,K75400222_PM0V060,K054504710PM0E050,K75200102_PM0E040,K75350621_PM0D040,K75500182_PM0N105,K75400202_PM0N077,K75420391_PM0D035,K75500102_PM0F077,K75500471_PM0E050,K75500561_PM0E050,K75350781_PM0D045,K75350331_PM0C040,K75400631_PM0E035,K75400221_PM0C035,K75400821_PM0E045,K75500271_PM0C050,K75250102_PM0E040,K75420391_PM0D040,K75 TYPE,K75500122_PM0F097,K75500681_PM0F060,K75450222_PM0V077,K75200182_PM0E040,K75,K75400272_PM0V077,K75400102_PM0E050,K75420202_PM0V060,K75500821_PM0F060,K75200332_PM0F060,K75400681_PM0E040,K75420821_PM0E050,K75500221_PM0D030,K75420471_PM0D040,K75420272_PM0N105,K75350781_PM0D050,K75500391_PM0E040,K75400631_PM0E040,K75400821_PM0E050,K□□□□□□□□□P□□ΦNNN,K75450272_PM0N105,K75250821_PM0E030,K75350371_PM0C040,K75250471_PM0C035,K75400102_PM0E060,K75420681_PM0E045,K75500331_PM0E040,K75400182_PM0N060,K75400471_PM0D040,K75350222_PM0N060,K75420102_PM0E060,K75350621_PM0E030,K75450471_PM0D045,K75500151_PM0C030,K75400371_PM0D030,K75450122_PM0F060,K75400471_PM0D035,K75350781_PM0E035,K75250222_PM0E060,K75450182_PM0N077,K75350102_PM0E045,K75500271_PM0D040,K75250102_PM0D050,K75350391_PM0D030,K75500221_PM0D040,K75350681_PM0D050,K75450681_PM0E045,K75450102_PM0E060,K75450182_PM0V060,K75450821_PM0E060,K75400511_PM0D040,K75420182_PM0N077,K75450471_PM0D050,K75200102_PM0E030,K75420352_PM0V105,K75350561_PM0D035,K75350901_PM0E040,K75250102_PM0E035,K75350472_PM0V105,K75400371_PM0D040,K75420681_PM0E050,K75250471_PM0C040,K75350372_PM0N105,K75400271_PM0C035,K75200561_PM0C030,K75250252_PM0F060,K75350681_PM0D045,K75500271_PM0D050,K75250391_PM0C030,K75450391_PM0D040,K75420331_PM0D040,K75450681_PM0E050,K75400271_PM0C040,K75400561_PM0D045,K75250122_PM0E040,K75350781_PM0E040,K75500681_PM0E060,K75420561_PM0D045,K75450331_PM0D040,K75400221_PM0C040,K75200102_PM0D035,K75400222_PM0F097,K75250821_PM0D040,K75350471_PM0D040,K75450221_PM0C040,K75200122_PM0E030,K75250761_PM0D040,K75420221_PM0C040,K75200681_PM0C040,K75350122_PM0E050,K75400331_PM0D030,K75200222_PM0E045,K75450471_PM0E035,K75400561_PM0D050,K75420621_PM0D050,K75350332_PM0V077,K75420132_PM0F060,K75420561_PM0D050,K75450331_PM0D035,K75420331_PM0D030,K75200821_PM0D030,K75250681_PM0C045,K75420251_PM0C035,K75350272_PM0N077,K75450271_PM0D030,K75450561_PM0D050,K75500221_PM0E030,K75200152_PM0D050,K75350681_PM0E040,K75350471_PM0D030,K75200222_PM0E050,K75250122_PM0D050,K75400511_PM0E030,K75450471_PM0E040,K75200272_PM0E060,K75350371_PM0C035,K75200102_PM0D040,K75250102_PM0D045,K75500151_PM0D030,K75350681_PM0E035,K75420202_PM0F097,K75500271_PM0E040,K75350102_PM0E050,K75450152_PM0N060,K75400561_PM0E035,K75420152_PM0N060,K75350272_PM0V060,K75200152_PM0D045,K75250681_PM0C050,K75420251_PM0C040,K75250761_PM0D035,K75420561_PM0E035

2024/6/6 - KENDEIL - 数据手册代理服务技术支持批量订货

Kendeil（肯德尔）铝电解电容器选型指南（英文）

目录- COMPANY PRESENTATION TECHNICAL INFORMATION CAPACITORS ACCESSORIES

型号- K04350153__M0L220,K05100102_PM0C030,K42400152__M0H105,K02063222__M0E060,K02063473__M0J143,K02250152__M0G079,K42,K41,K22350682__M0J214,K05025472_PM0C030,K13125600000000B2,K01075123__M0E079,K41450682__M0J214,K42100222__M0E060,K02400471__M0G079,K19400332__M0H105,K06450331_PM0E040,K42025153__M0E060,K42400103__M0L220,K76250761_PM0D035,K41075472__M0E060,K13125200000002B2,K01040334__M0J143,K06500331_PM0E050,K91450332__M0J105,K75400122_PM0E060,K41016154__M0H105,K72450222__M0G105,K55,K21450332__M0L098,K05200221_PM0B030,K92500332__M0J105,2,K07160103__M0G115,K07350392__M0H105,K76450681_PM0E040,K21350152__M0G079,K76500681_PM0E055,K41075103__M0G079,K71400303__M0L220,K61,K02200681__M0E060,K41400222__M0J105,K04500682__M0J214,K71450472__M0H105,K06050223_PM0F050,K01100683__M0J21,K22420682__M0J214,K05050223_PM0F050,K42250153__M0J214,K05450331_PM0E050,K06050103_PM0D040,K22400682__M0J214,K03400222__M0J143,K76500681_PM0E060,K42063153__M0G105,K03500222__M0L145,K04500392__M0J143,K75450222_PM0V077,K71,K76350921_PM0D050,K91400222__M0G105,K72,K07350332__M0H096,K05040472_PM0D025,K75,K03450152__M0J105,K76,K42450682__M0J214,K61080423__M0J143,K95420681_PM0E050,K02250102__M0G079,K01200681__M0E060,K91420222__M0G105,K42400222__M0J105,K05400821_PM0E060,K05450331_PM0E040,K95400681_PM0E050,K01450681__M0G079,K05500181_PM0D050,K03500152__M0J143,K07400392__M0H130,K13320050000002B2,K55450561_PM0E060,K13250315000003B2,K13320063000003B2,K02063473__M0J105,K13125800000001B2,K02450152__M0J105,K18400222__M0G105,K76350122_PM0E045,K07160333__M0J143,K42063333__M0J105,K07350182__M0G096,K07200143__M0H130,K85,K13125315000002B2,K01400681__M0E079,K76200681_PM0C035,K07450392__M0J105,K76400242_PM0N077,K76350881_PM0D045,K41100473__M0J143,K76350242_PM0N060,K01025224__M0H105,K42016154__M0H105,K05200102_PM0E030,K02450681__M0G079,K75450182_PM0V060,K13250250000003B2,K91,K72450822__M0J143,K93,K92,K22450103__M0L220,K95,K94,K41400152__M0H105,K06500152_PM0N097,K02016105__M0L220,K91500332__M0J105,K02200222__M0G079,K06200221_PM0B030,K02063683__M0H105,K02450123__M0L220,K42450152__M0J105,K42040154__M0J143,K11400233__M0L240,K91450332__M0J143,K41025103__M0E060,K07160822__M0G105,K21400152__M0G079,K21420152__M0G079,K13320031000002B2,K91450152__M0G105,K75350122_PM0E050,K13250063000003B2,K07350392__M0H115,K13250040000001B2,K42350222__M0J105,K75420251_PM0C035,K19450681__M0G079,K42025103__M0E060,K19400222__M0G105,K41250102__M0G079,K75400511_PM0E030,K95450221_PM0D030,K07450392__M0J115,K05450471_PM0E050,K04550222__M0J143,K42100682__M0G105,K26500561_PM0F050,K01200332__M0H105,K91400332__M0H105,K01075103__M0G079,K21400332__M0J098,K42350152__M0H105,K72350133__M0J143,K95350102_PM0E060,K21420332__M0J098,K06100102_PM0C030,K75250761_PM0D035,K76500222_PM0N105,K91420332__M0H105,K95350391_PM0D035,K95350681_PM0E040,K06550101_PM0D030,K85450391_PM0E045,K02400153__M0L220,K06200102_PM0E040,K01200222__M0G079,K07400153__M0L220,K41050333__M0G105,K22350222__M0H105,K07250682__M0G130,K95420821_PM0E060,K75250152_PM0E050,K01050473__M0G105,K76250102_PM0E035,K03400102__M0H105,K15420102_PM0F060,K41200472__M0G105,K72350292__M0G079,K21450472__M0L098,K04450222__M0H105,K85400151_PM0C030,K71450682__M0J105,K76450272_PM0N105,K76400442_PM0V105,K75200681_PM0C035,K26400152_PM0N060,K95350471_PM0C050,K02400222__M0J105,K02450682__M0J214,K06500221_PM0D050,K92450102__M0G105,K76450102_PM0E060,K02040683__M0J105,K01500332__M0J105,K21400332__M0J079,K02100682__M0G105,K01016155__M0L220,K42040104__M0J105,16035000000000000,K01200152__M0E060,K02100222__M0E060,K02100473__M0J143,K11400163__M0J240,K11450253__M0L220,K75500182_PM0N105,K02400152__M0H105,K22350123__M0L220,K04550152__M0H105,K06550561_PM0F077,K42450331__M0E079,K01075472__M0E060,K72450172__M0G079,K03450122__M0H105,K06400821_PM0E060,K42400471__M0G079,K02016154__M0H105,K26400202_PM0F105,K85350391_PM0C050,K01200152__M0E079,K16420102_PM0F060,K85420331_PM0C055,K95420391_PM0D040,K01016154__M0H105,K42040473__M0H105,K03475561__M0G105,K72420103__M0L105,K16450152_PM0V060,K15450152_PM0V077,K91450681__M0G079,K76420122_PM0E060,K41016473__M0G079,K75450272_PM0N105,K01160333__M0J214,K42040104__M0J143,K020401040HM0J143,K06600271_PM0F050,K01040223__M0E079,K01400222__M0J105,K76450202_PM0F097,K41040473__M0H105,K91450102__M0G105,K05200471_PM0C030,K04550682__M0L220,K71350682__M0H105,K07450272__M0H115,K11450183__M0J214,K55450561_PM0E050,K25400152_PM0N077,K75450102_PM0E060,K95450271_PM0D040,K76250152_PM0E050,K85400271_PM0E030,K01350222__M0G105,K04400152__M0H105,K76450391_PM0D035,K11400183__M0L240,K02016224__M0J105,K04400332__M0H105,K75420352_PM0V105,K75250102_PM0E035,K01100222__M0E060,K01350681__M0E079,K75250252_PM0F060,K15420152_PM0F097,K75450391_PM0D040,K18400332__M0H105,K76200821_PM0C040,K41450822__M0J214,K07450272__M0H105,K75500681_PM0E060,K01400153__M0L220,K05050103_PM0D040,K02025153__M0E060,K92420471__M0G079,K22420222__M0H105,K42100333__M0J143,K07250392__M0G096,K76250252_PM0F060,K13125250000002B2,K01250471__M0E060,K22400392__M0J105,K41250152__M0G079,K21400392__M0J105,K41500682__M0J214,K71400392__

2022/4/6 - KENDEIL - 选型指南代理服务技术支持批量订货

Kendeil铝电解螺旋式电容器产品变更

描述- Kendeil公司宣布，其铝电解螺丝型电容器的盖板将采用新型材料制造。新材料的颜色为黑色，而现有盖板的颜色为棕色。Kendeil将继续生产使用两种类型盖板的螺丝型电容器，包括多个系列和型号。新产品对客户的影响包括：盖板设计先进，外部尺寸不变，订购代码未变。更多详情请咨询Kendeil技术或销售服务。

型号- K91,K71,K92,K61,K72,K42,K41,K11,K22,K21,K02,K01,K04,K03,K07

January 2018 - KENDEIL - 产品变更通知及停产信息代理服务技术支持批量订货

K85型-40°C+105°C 8000H

描述- 该资料介绍了K85型铝电解电容器的技术规格和应用。它适用于高纹波电流和超长寿命应用，具有耐浪涌电压的特性。资料提供了详细的尺寸、额定电压范围、容值、损耗角正切最大值、等效串联电阻等参数，并包含了不同型号的电容器标准额定数据。

型号- K85350331_PM0C045,K85450391_PM0E045,K85350681_PM0E045,K85400471_PM0D055,K85420391_PM0E040,K85,K85450331_PM0E040,K85350102_PM0E060,K85400391_PM0E040,K85350561_PM0E040,K85450561_PM0E060,K85450181_PM0D035,K85450151_PM0D030,K85400681_PM0E055,K85400151_PM0C030,K85400331_PM0C055,K85400331_PM0E035,K85450221_PM0D040,K85350721_PM0E050,K85420271_PM0D040,K85400271_PM0C050,K85400271_PM0E030,K85350391_PM0D040,K85350681_PM0E050,K85400221_PM0C045,K85450271_PM0D045,K85450101_PM0C030,K85420151_PM0C035,K85420561_PM0E055,K85350471_PM0E035,K85420181_PM0D030,K85420251_PM0D035,K85450151_PM0D040,K85400181_PM0D030,K85450561_PM0E055,K85420221_PM0C045,K85420391_PM0D055,K85350471_PM0C055,K85420681_PM0E060,K85350331_PM0D035,K85450391_PM0D055,K85350391_PM0D035,K85400471_PM0E045,K054504710PM0E050,K85450331_PM0D050,K85400391_PM0D050,K85420251_PM0C050,K85350221_PM0C035,K85420251_PM0E030,K85420471_PM0E050,K85450181_PM0C045,K85450151_PM0C040,K□□□□□□□□□P□□ØNNN,K85350561_PM0D055,K85450221_PM0C050,K85450221_PM0E030,K85400561_PM0E050,K85400331_PM0D040,K85400181_PM0C035,K85 TYPE,K85350391_PM0C050,K85350391_PM0E030,K85400221_PM0D035,K85420331_PM0C055,K85420121_PM0C030,K85420331_PM0E035,K85450271_PM0E035,K85350821_PM0E055,K85450681_PM0E077,K85350181_PM0C030,K85450121_PM0C035,K85350221_PM0D030,K85450471_PM0E050,K85420221_PM0D035,K85400271_PM0D035

2023/9/6 - KENDEIL - 数据手册代理服务技术支持批量订货

钽电容的漏电流是不是相比电解电容小很多？一般是多大的？电解电容的漏电流呢？

恰恰相反，一般情况钽电解电容比电解电容漏电流大些，一般的漏电流为0.04 Cr Vr μA，其中漏电流IL= K* Cr Vr，单位是μA，K是常数，不同厂家K值的标定也不一样，世强代理的Kendeil 铝电解电容漏电流ILmax= 0.003 Cr Vr μA，K值为0.003，同类产品已经是非常小的了。

2017-09-20 - 技术问答

K55型-40°C+105°C 6000小时

描述- 本资料介绍了K55型铝电解电容器的规格和应用。该系列产品专为太阳能逆变器和专业电源设计，具有高体积比CV、低ESR、高纹波电流和长寿命等特点。资料提供了详细的尺寸、电压范围、容值、耐压、漏电流、绝缘电阻等参数，并说明了其工作温度范围为-40°C至+105°C。

型号- K55450471_PM0E050,K55450471_PM0D050,K054504710PM0E050,K55,K55450391_PM0D050,K55450821_PM0F060,K55 TYPE,K55450681_PM0E050,K55450681_PM0E060,K□□□□□□□□□P□□ØNNN,K55450561_PM0E060,K55450561_PM0E050,K55450331_PM0E040,K55450331_PM0D040

2023/9/6 - KENDEIL - 数据手册代理服务技术支持批量订货

Kendeil K75 电解电容数据手册

描述- 该资料介绍了K75型电容器的设计和应用。这种电容器专为极小化设计，具有铝罐绝缘套管和夹紧端子，适用于专业应用，如超紧凑UPS、太阳能逆变器、高纹波电流转换器和电机驱动器。

型号- K75200102_PM0C045,K75420202,K75200122_PM0D040,K75250761,K75450332_PM0V105,K75350371,K75350372,K75200821,K75400272,K75420681,K75400152,K75420561,K75400271,K75400392,K75200821_PM0C040,K75420242_PM0V077,K75450561_PM0E040,K75400122_PM0E060,K75450221_PM0C035,K75450182_PM0F097,K75350821_PM0D050,K75420221_PM0C035,K75250561_PM0D030,K75350122,K75400292_PM0N105,K75400821_PM0D060,K75420102,K75420221,K75450821_PM0E050,K75200122_PM0C050,K75350391,K75400222_PM0V060,K75350272,K75350152,K75350621_PM0D040,K75400202_PM0N077,K75420391_PM0D035,K75400292,K75400221_PM0C035,K75400821_PM0E045,K75200272,K75200152,K75420331,K75450222_PM0V077,K75,K75400102_PM0E050,K75400182,K75350821,K75200332_PM0F060,K75420821_PM0E050,K75250681,K75250821_PM0E030,K75250471_PM0C035,K75200182,K75350292,K75250561,K75420681_PM0E045,K75400182_PM0N060,K75400471_PM0D040,K75420102_PM0E060,K75400471,K75450471_PM0D045,K75450122_PM0F060,K75400471_PM0D035,K75250222_PM0E060,K75450182_PM0V060,K75400511_PM0D040,K75420182_PM0N077,K75200102_PM0E030,K75400122,K75350561_PM0D035,K75450182,K75250122_PM0E040,K75200102_PM0D035,K75250821_PM0D040,K75350122_PM0E050,K75400371,K75450471_PM0E035,K75450391,K75450271,K75420132_PM0F060,K75450272,K75450331_PM0D035,K75420251_PM0C035,K75350272_PM0N077,K75450271_PM0D030,K75450561_PM0D050,K75450152,K75350471_PM0D030,K75400821,K75420651,K75250122_PM0D050,K75400511_PM0E030,K75200272_PM0E060,K75350371_PM0C035,K75350621,K75420202_PM0F097,K75420152_PM0N060,K75250761_PM0D035,K75400152_PM0F060,K75250122,K75250152_PM0E050,K75400331_PM0C040,K75400631_PM0D045,K75420651_PM0E040,K75400392_PM0V105,K75250471,K75200681_PM0C035,K75450821,K75350202_PM0F060,K75400202,K75350152_PM0E060,K75420391,K75400681,K75400561,K75420272,K75420152,K75350331_PM0C035,K75350292_PM0F097,K75400681_PM0D050,K75420471_PM0E030,K75200152_PM0E035,K75200681,K75200561,K75250102,K75250222,K75420621,K75400331,K75420182,K75350781_PM0D045,K75400631_PM0E035,K75450471,K75200182_PM0E040,K75400102,K75400221,K75400272_PM0V077,K75400222,K75350781,K75420202_PM0V060,K75400681_PM0E040,K75420471_PM0D040,K75420272_PM0N105,K75450122,K75450272_PM0N105,K75400511,K75400631,K75350222_PM0N060,K75350331,K75200222,K75350621_PM0E030,K75350332,K75420242,K75200102,K75400371_PM0D030,K75350781_PM0E035,K75450182_PM0N077,K75350102_PM0E045,K75350391_PM0D030,K75450332,K75450681_PM0E045,K75450102_PM0E060,K75450331,K75250152,K75350681,K75350561,K75420352_PM0V105,K75250391,K75350901_PM0E040,K75200332,K75250102_PM0E035,K75350472_PM0V105,K75420352,K75350202,K75350372_PM0N105,K75400271_PM0C035,K75420471,K75200561_PM0C030,K75250252_PM0F060,K75350681_PM0D045,K75250391_PM0C030,K75450391_PM0D040,K75400561_PM0D045,K75450222,K75450102,K75420561_PM0D045,K75450221,K75400222_PM0F097,K75420821,K75200122_PM0E030,K75350471,K75400331_PM0D030,K75350472,K75200122,K75200222_PM0E045,K75350332_PM0V077,K75420331_PM0D030,K75200821_PM0D030,K75250681_PM0C045,K75250821,K75250252,K75200222_PM0E050,K75250102_PM0D045,K75350222,K75420132,K75350102,K75420251,K75350681_PM0E035,K75420621_PM0D060,K75450152_PM0N060,K75350901,K75400561_PM0E035,K75350272_PM0V060,K75200152_PM0D045,K75450681,K75420561_PM0E035,K75450561

2016年07月27日 - KENDEIL - 数据手册代理服务技术支持批量订货